SpaceX debuts new model of the Falcon 9 rocket designed for astronauts – Spaceflight Now (original) (raw)

SpaceX’s Falcon 9 rocket lifts off Friday from launch pad 39A. Credit: SpaceX

SpaceX debuted a more reusable, higher-thrust model of the Falcon 9 rocket Friday, hauling Bangladesh’s first communications satellite into orbit from Florida’s Space Coast.

The successful launch propelled SpaceX closer to launching astronauts for NASA, which will fly on the same “Block 5” model of the Falcon 9 rocket that flew Friday.

Musk said the enhanced launch vehicle will also be easier to reuse, moving toward the California-based space transport company’s ambitious mission of drastically cutting launch costs and building settlements on other worlds.

The launcher’s window-rattling blastoff from Kennedy Space Center’s pad 39A, the historic complex once used by NASA’s Saturn 5 moon rocket and numerous space shuttle missions, occurred at 4:14 p.m. EDT (2014 GMT) Friday.

Turning toward the east, the 229-foot-tall (70-meter) Falcon 9 rocket arced over the Atlantic Ocean with the Bangabandhu 1 communications satellite, a French-built spacecraft destined to provide television and data relay services for the Bangladesh Telecommunication Regulatory Commission.

A launch try Thursday ended at T-minus 1 minute after computers on-board the Falcon 9 detected an out-of-bounds parameter. No such glitches appeared during Friday’s countdown.

In a feat once considered by many to be too daunting to attempt, the Falcon 9’s 15-story first stage booster made a pinpoint landing on SpaceX’s sea-going drone ship “Of Course I Still Love You” parked nearly 400 miles (630 kilometers) east of Cape Canaveral in the Atlantic Ocean.

The first stage of the Falcon 9 Block 5 rocket after landing on SpaceX’s drone ship Friday. Credit: SpaceX

After dropping away from the rocket’s upper stage two-and-a-half minutes into the mission, the booster pulsed thrusters fed by pressurized nitrogen gas to flip around to fly tail first, then reignited a subset of its nine engines to steer toward the recovery barge and slow down for landing.

Four titanium winglets extended from the top of the first stage to stabilize the cigar-shaped vehicle, and four landing legs unfurled at the bottom of the rocket just before touchdown.

The on-target landing was the 25th time SpaceX has retrieved one of its Falcon rocket boosters intact after a space launch. Fourteen of the landings have come on one of the company’s drone ships at sea, and SpaceX has returned 11 rockets to land for inspections or reuse.

Like all its launches, SpaceX’s chief objective on Friday’s mission was the deployment of the Bangabandhu 1 satellite in orbit. Two burns by the Falcon 9’s upper stage engine, a Merlin powerplant optimized for in-space maneuvers, guided the roughly 8,200-pound (nearl 3,750-kilogram) payload into an elliptical geostationary transfer orbit for separation around 33 minutes after liftoff.

Named for Bangabandhu Sheikh Mujibur Rahman, the father of the Bangladeshi nation who was assassinated in 1975, the spacecraft will provide telecom, television and other data services to Bangladesh and neighboring regions during a 15-year mission.

The satellite was built by Thales Alenia Space of Cannes, France, which also took charge of developing an operations center in Bangladesh, training Bangladeshi engineers, and arranging for the craft’s launch on a SpaceX Falcon 9 rocket.

The guidance computer on-board the Falcon 9 aimed to release Bangabandhu 1 into an orbit ranging between 186 miles (300 kilometers) and 22,186 miles (35,706 kilometers) in altitude, tilted at an inclination of 19.3 degrees to the equator, according to Gilles Obadia, Thales’ program manager for the mission.

An official from Thales Alenia Space said after Friday’s launch that ground controllers in Cannes established contact with the Bangabandhu 1 satellite in orbit.

Artist’s concept of the Bangabandhu 1 satellite. Credit: Thales Alenia Space

Bangabandhu 1’s on-board engine will circularize its orbit at geostationary altitude within the first 11 days of the mission, Obadia said, to begin several weeks of in-orbit testing before Thales hands over control of the spacecraft to its Bangladeshi end user.

The satellite will be parked in geostationary orbit more than 22,000 miles over the equator, locking its velocity to match Earth’s rotation at a position at 119.1 degrees east longitude. Bangabandhu 1 carries 26 Ku-band and 14 C-band transponders.

Once the Falcon 9’s first stage returns to Port Canaveral in a few days, engineers will inspect and disassemble parts of the Block 5 booster to study how it performed. Eventually, the upgrades debuting on the Falcon 9 Block 5 will allow the first stage booster to be reused 10 times without refurbishment, Musk said.

“We are going to be very rigourous in taking this rocket apart and confirming our design assumptions to be confident that it is indeed able to be reused without being taken apart,” he said. “Ironically, we need to take it apart to confirm that it does not need to be taken apart. So this rocket probably won’t re-fly for a couple of months.”

Boosters based on the upgraded Block 5 model, which Musk said is actually “Version 6” of the Falcon 9 rocket, could fly hundreds of times, delivering satellites, cargo ships and astronauts to space, the billionaire entrepreneur told reporters Thursday before the mission’s first launch attempt.

It will ultimately be replaced by the Big Falcon Rocket, an enormous rocket SpaceX is developing that the company says will generate more power than any launch vehicle in history.

The BFR is expected to begin flying space missions in the 2020s.

“This will be the last major version of Falcon 9 before BFR,” Musk said. “We expect this to be a mainstay of SpaceX’s business. We think (it) will probably wind up with something on the order of 300 flights, maybe more, of Falcon 9 Block 5 before retirement.”

Credit: Walter Scriptunas II/Spaceflight Now

He said the Block 5’s first stage booster is designed to fly 10 times “with no scheduled refurbishment.” With “moderate scheduled maintenance,” Block 5 first stages could be capable of 100 missions, Musk said.

Between 30 and 50 boosters for Falcon 9 Block 5 vehicles could be manufactured to meet customer demand, each flying multiple times, he said.

“Just to give you a sense of how reusable we think it will be, we intend to demonstrate two orbital launches of the same Falcon 9 vehicle within 24 hours no earlier than next year,” Musk said. “It’s going to take some time because we’re going to be careful and deliberate about this.”

Musk said the most important changes to the Block 5 address NASA human-rating requirements, ahead of the planned launches of astronauts to the International Space Station on Falcon 9 rockets beginning late this year or some time in 2019.

“The intent is for (Falcon 9 Block 5) to be the most reliable rocket ever built,” Musk said. “That is certainly the intent, and I think our most conservative customers would agree.”

For crewed missions, the structural components of a rocket must withstand higher stress than parts used on a typical satellite launcher.

“The rocket has to be designed to 25 percent above the worst case of the expected load in the case of a satellite launcher,” Musk said. “For a human-rated launcher, it has to be designed 40 percent above the worst-case loads … That’s really difficult to do without making the rocket really heavy. That’s hardcore stuff.”

The Falcon 9 Block 5’s avionics are also multi-fault tolerant, meaning the rocket can still reach orbit after multiple system failures.

The rocket’s modifications also provide an uptick in performance.

There’s an 8 percent increase in sea level thrust from the Falcon 9’s nine Merlin first stage engines, up to around 190,000 pounds of thrust each, Musk said. The upper stage’s single vacuum-rated Merlin engine on Block 5 can generate 220,000 pounds of thrust, but was to be throttled back to 210,000 force-pounds on Friday’s mission.

“Both the efficiency of the engine and thrust of the engine have increased, (without) any material change to the mass of the engine. The thrust-to-weight ratio is truly incredible at this point. It was already the highest thrust-to-weight engine in the world.”

Musk also addressed changes to the outer coating of the rocket, aimed at better shielding the first stage from extreme re-entry temperatures.

“We also have a lot of new thermal protection technology,” Musk said. “If you look, aesthetically, there’s the black interstage. That is the structure that joins the upper and lower stage, as well as the raceways, the landing legs, they all use a new thermal protection material developed at SpaceX, which is highly reusable and does not require paint. It’s hydrophobic. It does not trap water. This was quite a challenging thing to do.

“I kind of like the aesthetics of it more,” he said. “If you look back at the old Falcon 1 rocket, I really like having the black interstage. The interstage is made of carbon fiber. It adds a different aesthetic to the rocket. Obviously, aesthetics are a minor factor in designing a rocket.”

The octaweb, a structure which contains the first stage’s nine engines at the base of the rocket, is also made of a higher-strength aluminum. It’s bolted on the base of the Falcon 9 Block 5, while it was welded to the booster on previous versions of SpaceX’s workhorse vehicle.

“It also has quite a bit of thermal protection on the inside in case of an engine fire or something like that, so that it does not melt the octaweb.”

The first stage’s four landing legs also sport changes.

The locking mechanism that kept the legs deployed during the booster’s final descent and post-flight processing has been removed. The landing gear now has an internal locking system, Musk said.

“Opening the landing gear and closing the landing gear is now a very easy thing to do, whereas previously it required a couple of hours to re-stow the landing gear. That can now be done with an actuator.”

The heat shield attached to the bottom of the rocket near the booster’s engine section has also been beefed up.

“We replaced the old composite structure with a high-temperature titanium structure to support rapid reuse,” Musk said. “The base heat shield will also be, in some parts, actively cooled with water.”

He said data crunched from past Falcon 9 flights indicated that some parts of the base of the launcher exposed to super-hot temperatures during the rocket’s hypersonic re-entry needed better protection.

“You kind of have to use a high-melting point material, a high-temperature material, plus active water cooling in certain places on the base of the heat shield.”

To sum up the Block 5 upgrades, Musk said the new Falcon 9 configuration is a “bit better in every way.”

“It has a better flight computer, engine controllers, a new, more advanced inertial measurement system.”

Other improvements that will fly regularly on the Falcon 9 Block 5 have already been demonstrated during past Falcon 9 missions. Those include a new-generation payload fairing, which covers satellite payloads during launch, to make the shroud recoverable and reusable. Titanium grid fins, which likewise have already made their debut on previous Falcon 9 missions, will fly on every Block 5 launch, replacing aluminum steering winglets used on descent that were susceptible to heat damage.

SpaceX engineers also added a permanent fix on the Block 5 upgrade to resolve a concern with turbine wheel cracks inside the Merlin engine’s turbopump, and new helium tanks that are not susceptible to pooling frozen liquid oxygen and friction that led to the explosion of a Falcon 9 rocket on the launch pad in 2016.

Both changes were meant to make the Falcon 9 compliant with NASA human-rating safety standards.

SpaceX has a $2.6 billion contract with NASA to complete development of Crew Dragon, a capsule to ferry astronauts to and from the International Space Station. NASA awarded Boeing a similar deal, giving the agency two U.S. crew transport providers and ending U.S. reliance on Russian Soyuz vehicles for the job.

The first unpiloted test flight of the Crew Dragon is scheduled as soon as late August, but the demo mission could be delayed. A two-person Crew Dragon test flight to the space station could follow by the end of the year, but top NASA managers have said they expect SpaceX and Boeing crewed demonstrations to launch in 2019.

NASA will require seven successful flights of the Falcon 9 Block 5 before flying astronauts on the rocket.

“In human spaceflight, demonstration ‘testing like we fly’ is a long standing tenant for safe operations and understanding of critical systems,” said Cheryl Warner, a NASA spokesperson, in a statement. “Test flights offer a tremendous opportunity to learn, and the commercial crew program, along with SpaceX, will provide rigorous insight into the SpaceX launch manifest and any necessary configuration changes resulting from the test flights.”

Friday’s launch was SpaceX’s ninth mission so far this year. By this time in 2017, SpaceX had achieved five launches of the 18 flights the company logged by the end of the year.

“We’re on track to double our launch rate from last year, which was a record launch rate for us,” Musk said.

Email the author.

Follow Stephen Clark on Twitter: @StephenClark1.